Logistics: The Cold Light Of Victory


September 10, 2012: The latest energy saving device in Afghanistan is the LED light bulb. While lighting consumes less than two percent of the fuel shipped to the war zone (heating and air conditioning get 12 percent and aircraft more than half), the LED bulbs (which generate little heat) consume only 15 percent of the electricity required by incandescent bulbs and less than half what fluorescent fixtures use. Plus the LED bulbs last longer and are more rugged. While the overall savings is small, it is appreciated. Combat troops are already very familiar with LED lighting as they have been using lightweight LED lights (often mounted on their weapons) for years and noted that the batteries last a lot longer on LED flashlights while producing the same amount of light as the older incandescent bulb units.

American army and marine commanders are desperate to reduce fuel consumption. They point out that during World War II, the first war in which American forces were mechanized, each soldier required 4-5 liters (one gallon) of fuel per day. But by 2003, and the invasion of Iraq, fuel consumption was twenty times higher. In reality this meant that when you sent a modern mechanized division into combat you had to supply those troops at the rate of 80-120 liters (20-30 gallons) of fuel per man per day. As the 3rd Infantry Division moved from Kuwait to Baghdad in 2003, some 20,000 troops were involved. That required some 200 tanker loads of fuel per day. Initially, the vehicles in the division carry enough fuel to go 200-300 kilometers on internal fuel. But you don't want your vehicles to run until their tanks are dry, so at least once a day you try to top everyone off. The route of the 3rd Infantry Division covered about 700 kilometers of road. In addition to fuel, you need about a 45-90 kg (100-200 pounds) of other supplies per man per day (mostly ammo, but also batteries, food, and the like). Once inside Baghdad, and no longer moving all the time, the fuel requirement came way down. But on the march the advancing combat brigades were tethered by convoys of fuel trucks going back and forth to the supply bases in Kuwait. But once the U.S. began building bases for the combat brigades, it was found that the use of generators, especially for air conditioning, kept fuel requirements high (over 80 liters per man per day), which is why most of the supply trucks were still carrying fuel.

There are no easy solutions for this. Vehicles are larger and require more fuel than they did 70 years ago. Tanks weigh twice as much, as do most other armored vehicles. There are more trucks and armored vehicles, as well as a lot more electronic equipment and air conditioning to keep it cool. It was found that air conditioned living quarters were a huge boost to morale and a way to reduce combat stress. That required lots of fuel. So far, the army and marines have sought to equip the troops with more energy sources that do not require fuel to be trucked, or flown, in. This is especially important for troops who are out on operations that might last a few days.

Batteries, and the fuel to run generators for recharging, have become a major supply item. For example, a three day operation by an infantry platoon (30 men), consumes six kg (6.6 pounds) of batteries per man. Rechargeable batteries cut that by more than half, as long as you have some way to recharge them. Special Forces are hit particularly hard by this, as they often have to go in by foot, to avoid detection, and set up a surveillance operation that consumes a lot of batteries. This is very common in Afghanistan.

Solutions are being sought. For example, two years ago a company (about 200 personnel) of American marines conducted a desert training exercise to see how long they could run their equipment using solar power. Solar panels were incorporated into equipment (like a cloth like panel that was draped over a tent) or set up with a number of solar panels to act as a "solar generator." As a result, for eight straight days, the marines were able to power all their radios and laptops (by recharging batteries) via solar panels. There is a lot of other battery powered gear but radios and laptops are the big energy eaters. Feed them and you have eliminated most of the power demand for troops operating on foot. The equipment and techniques used doing this are now being transferred to marines in Afghanistan. This sort of thing saves lives and money. Marines have to guard a lot of their supply convoys, two-thirds of them carrying fuel or water, and for every 45 truckloads brought in a marine is killed or wounded. This is sometimes avoided by hiring locals to provide convoy security but that option often creates another warlord in the area.

Thus, all American commanders in Afghanistan want more renewable fuel sources. Combat commanders have done the math and with more combat units out and about these days, they are demanding more solar panels and fuel cells in order to lower the demand for generator fuel and batteries. With all those computers and electronic gadgets out there, the demand for electricity, especially by units in combat, is huge.

For decades it was believed that hydrogen powered fuel cells would replace fossil fuel (JP-5, similar to jet fuel) powered generators. But fuel cells have been the next-big-thing for nearly a century. That said, small fuel cells are beginning to appear. The U.S. Army is installing them in tanks and trucks, as a source of auxiliary power. This points out that the larger fuel cells are now quite ready to replace the large generators (the main consumer of all that fuel). While the fuel cells cost more than ten times as much as JP-5 powered generators, that JP-5 costs about 40 times more than the same fuel used back in the United States. That's because of the transportation cost (up to $25/liter or $100/gallon) of fuel. Thus fuel cells are still a cheaper alternative and the more expensive fuel cell generator quickly pays for itself in a combat zone, and saves the lives of those operating and protecting all those fuel convoys. Another use for small fuel cells is to ease the growing load of batteries carried into combat.

A major problem with these small fuel cell devices is that it is mainly for items like cell phones and iPods, or anything that can get its charge via a USB connector. For military use, you need a device that can recharge common batteries and specialized ones for military equipment. Technically, that is a simple matter, as is scaling up the current miniature fuel cell devices (about the size of a hand held game player) to provide more power. The problem with fuel cells remains their temperamental technology and high cost. But the military is willing to buy one that can stand rough handling, even at a high price, because of the even higher cost of getting fuel to the combat zone.


Article Archive

Logistics: Current 2022 2021 2020 2019 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2008 2007 2006 2005 2004 2003 2002 2001 2000 1999 



Help Keep Us Soaring

We need your help! Our subscription base has slowly been dwindling. We need your help in reversing that trend. We would like to add 20 new subscribers this month.

Each month we count on your subscriptions or contributions. You can support us in the following ways:

  1. Make sure you spread the word about us. Two ways to do that are to like us on Facebook and follow us on Twitter.
  2. Subscribe to our daily newsletter. We’ll send the news to your email box, and you don’t have to come to the site unless you want to read columns or see photos.
  3. You can contribute to the health of StrategyPage. A contribution is not a donation that you can deduct at tax time, but a form of crowdfunding. We store none of your information when you contribute..
Subscribe   Contribute   Close