Murphy's Law: F-22 Magic Backfires

Archives

February 24, 2009: The U.S. Air Force's new F-22 aircraft is proving more difficult to maintain than planned. Because of the time required to maintain the stealth features of the aircraft, only 60 percent of them are available for service at any given time. Non-stealth fighters have a readiness rate of 70-80 percent. This is not a new problem.

As recently as three years ago, only about seven of the U.S. Air Force's 21 B-2 bombers were ready to go at any time. The air force was already trying to solve the problem, using a combination of robots, sprayers and quality control in an attempt to double the readiness rate. This was essential, because the B-2 was frequently getting called a "Hangar Queen" (an aircraft that spends too much time in the hangar for maintenance or repairs).

Five years ago, the U.S. Air Force introduced the use of robots to reduce the maintenance efforts required to keep their B-2 bombers flying. The B-2 uses a stealth (anti-radar) system that depends a lot on a smooth outer skin. That, in turn, requires that the usual access panels and such on the B-2 must be covered with tape and special paste to make it all smooth. The F-22 uses a similar system. After every flight, a lot of this tape and paste has to be touched up, either because of the result of flying, or because access panels had to be opened. All this takes at lot of time, being one of the main reasons the B-2 required 25 man hours of maintenance for each hour in the air. Since most B-2 missions have been 30 or more hours each, well, do the math. The readiness rate of the B-2 fleet (of 21 aircraft) has been about 35 percent, which was less than half the rate of most other aircraft. This means, that whenever there is a crises that requires the attention of B-2s, there are not many of these bombers ready to fly.

The main base for B-2s is in Missouri, and over a thousand maintenance personnel were assigned to take care of 21 aircraft there. A team of four robots were installed, to liquid coating to B-2s, thus cutting maintenance hours in half. But there were quality control problems with the liquid coating, often forcing maintenance crews to go back to tape and paste. Eventually, the quality control problems were solved, and, readiness rate of B-2s went up to over 50 percent.

B-2s still require a special, climate controlled hangars. There are some portable B-2 hangars, that can be flown to distant bases, thus keeping the bombers in the air less, and reducing the amount of maintenance needed. B-2 quality hangars were built at Guam, in the Pacific, and Diego Garcia in the Indian ocean

Still, the cost to operate the B-2 is over three times that of the B-52. If stealth is not an issue (not much enemy opposition), than it's a lot cheaper to send a B-52. This is exactly what the air force does most of the time. But in a war with a nation possessing modern (or even semi-modern) air defenses, the B-2s can be very valuable. Costing over two billion dollars each to buy, and very expensive to operate, the B-2s provide that extra edge. No other nation has anything like the B-2s, although many are working on ways to defeat it's stealth and knock them down. When equipped with over a hundred of the new SDB (250 pound, GPS guided Small Diameter Bomb), the B-2 can be a formidable one-plane air force.

F-22 do for air-superiority what the B-2 does for defeating enemy air defenses. While many nations claim they can defeat the American stealth capabilities, no one has proven it yet, and no one really wants to be the first to try.

 

X

ad

Help Keep Us From Drying Up

We need your help! Our subscription base has slowly been dwindling.

Each month we count on your contribute. You can support us in the following ways:

  1. Make sure you spread the word about us. Two ways to do that are to like us on Facebook and follow us on Twitter.
  2. Subscribe to our daily newsletter. We’ll send the news to your email box, and you don’t have to come to the site unless you want to read columns or see photos.
  3. You can contribute to the health of StrategyPage.
Subscribe   contribute   Close