Air Transportation: K-Max Gets A Hot Hookup


June 8, 2012: On May 22nd, for the first time, cargo was hooked up to a sling from a hovering K-Max UAV helicopter. This is called a hot hookup and when done with a manned helicopter you have the pilots and a crew chief supervising the operation from the helicopter. Now the marines have shown that the K-Max is capable enough to handle it just using the remote operators and the UAVs flight control software.

The U.S. Marine Corps have been testing the K-Max in Afghanistan since last November. Last December the K-Max made its first cargo flight, taking 90 minutes to deliver 1.5 tons of supplies to a distant outpost. Since then the K-Max has delivered over 500 tons of cargo to remote marine bases in Afghanistan.

It was only seven months ago, on December 17th, that a K-Max in Afghanistan made its first combat supply delivery, bringing 1.5 tons of food and other items to a combat outpost. The mission took 90 minutes. Two K-Maxes arrived in Afghanistan last November and were to depart in May. But the K-Max has proved so useful that both of them will remain until September.

The marines began looking for a cargo carrying helicopter UAV in 2009, and quickly determined that K-Max was the best candidate for further development and testing. The two K-Max UAVs in Afghanistan are there as a final test of how useful the vehicle could be in a combat zone. An unmanned cargo helicopter risks fewer lives and is cheaper to operate. It can also be used in extremely hazardous missions.

The K-Max UAV was originally designed as a single seat helicopter that could carry sling loads of 2.8 tons (6,000 pounds) at sea level, or two tons (4,300 pounds) at 4,800 meters (15,000 feet). The 5.5 ton K-Max has a cruise speed of 185 kilometers an hour and can stay in the air for 2.6 hours per sortie. One of the most attractive features of the K-Max is the amount of automation in the aircraft. The flight control software can be programmed with where to take and drop a cargo, then return and land automatically. The operator can intervene at any time, but most of the time the operator just monitors vidcams attached to the K-Max to ensure nothing goes wrong.

In 2010, the U.S. Army conducted tests using a K-Max to deliver supplies via parachute. This involved using the army low altitude parachute, which can drop loads of 36 kg (80 pounds) to 273 kg (600 pounds) at heights of 48-100 meters. The K-Max had a special rig that could carry and release four different payloads and demonstrated its ability to drop each one at a different location. The low altitude drops are more accurate than higher altitude ones and useful where the troops getting the stuff are on hilly ground that has few good helicopter landing zones. The army is also testing K-Max dropping loads from higher altitudes, using GPS guided parachutes. The army and marines are planning to have their helicopter UAVs to drop supplies via parachute to troops in isolated areas. If the army makes this work the marines will use these delivery techniques as well.


Article Archive

Air Transportation: Current 2022 2021 2020 2019 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2008 2007 2006 2005 2004 2003 2002 2001 1999 



Help Keep Us Soaring

We need your help! Our subscription base has slowly been dwindling. We need your help in reversing that trend. We would like to add 20 new subscribers this month.

Each month we count on your subscriptions or contributions. You can support us in the following ways:

  1. Make sure you spread the word about us. Two ways to do that are to like us on Facebook and follow us on Twitter.
  2. Subscribe to our daily newsletter. We’ll send the news to your email box, and you don’t have to come to the site unless you want to read columns or see photos.
  3. You can contribute to the health of StrategyPage. A contribution is not a donation that you can deduct at tax time, but a form of crowdfunding. We store none of your information when you contribute..
Subscribe   Contribute   Close