The Perfect Soldier: Special Operations, Commandos, and the Future of Us Warfare by James F. Dunnigan

More Books by James Dunnigan

Dirty Little Secrets

DLS for 2001 | DLS for 2002 | DLS for 2003
DLS for 2004 | DLS for 2005 | DLS for 2006
DLS for 2007 | DLS for 2008

Cannot Get Enough Excalibur
by James Dunnigan
September 13, 2008

Discussion Board on this DLS topic

The U.S. Army has ordered another thousand Excalibur, 155mm, GPS guided artillery shells, at a cost of about $85,000 each. Australia ordered 250 of the shells earlier this year. American and Canadian troops have begun using the Excalibur shell in Afghanistan earlier this year. A year ago, American troops began using Excalibur in Iraq.

This was timely, because Islamic warriors tend to use civilians as human shields, and that means you have to be precise when you go after the bad guys. The Excalibur shell enabled the artillery to take care of these chores. A typical situation has enemy gunmen holding out in one building of a walled compound or village. In nearby buildings, there are women and children. While killing the enemy is good, killing the civilians can be a very bad thing. Smart bombs should be able to fix this, except that sometimes one of the smaller smart bombs, the 500 pounder, has too much bang (280 pounds of explosives).

A 155mm artillery shell should do the trick (only 20 pounds of explosives each), but at long range (20 kilometers or more), some of these shells will hit the civilians. That's because at that range, an unguided 155mm shell can land up to 100-200 meters from where you aimed it. This is where Excalibur comes in handy. The GPS guided Excalibur shell falls within a ten meter circle (the middle of that circle being the "aim point") no matter what the range.

After a year of use in Iraq, the troops find Excalibur invaluable for hitting just what you want to hit, and with a minimal amount of bang. Excalibur, being an artillery (which is controlled by the army) weapon, is easier to call in than a smart bomb (air force) attack. U.S. Army attack helicopters also have their Hellfire missiles, which provide a bit less bang than the Excalibur shell (and cost about the same). But while weather (especially sand storms) can interfere with helicopter operations, Excalibur is always ready to fire.

For most nations, the big drawback with Excalibur is cost. A "dumb" 155mm shell costs $300 or less, but when you take into account the civilian lives saved (and good will retained), it's a different story. Moreover, friendly troops can be closer to the target when Excalibur is used, meaning your infantry can get into the shelled target quicker, before any surviving enemy can get ready to shoot back.

The Excalibur shell is worth it in other ways. Ten 155mm shells (of any type, with their propellant and packaging) weigh about a ton. Ammo supply has always been a major problem with artillery, and Excalibur is the solution. With Excalibur, fewer 155mm shells have to be shipped thousands of miles, and looked after until they are used. One Excalibur shell can take out a target that would require 10-20 unguided shells.

Excalibur was developed in the United States, in cooperation with Swedish engineers, The Excalibur was originally supposed to cost under $50,000 each, and with more being produced, the per-shell price may eventually fall to the planned price. Currently, 150 Excaliburs are being produced each month, and the army wants to double that. Developing electronics and control systems that fit inside a 155mm diameter shell, and survive being fired out of a cannon, proved more difficult than expected. That's why a GPS guided smart bomb only costs about $30,000, while the first hundred or so Excaliburs cost more than twice as much.

Developing smart artillery shells is risky. The U.S. Navy recently cancelled a project to develop a similar 127mm shell, and is now looking into adopting the Excalibur technology for a GPS guided 127mm shell that works. Smart shells are a nice idea, but getting from here to there is a risky and expensive process.

© 1998 - 2023 All rights Reserved.,, FYEO, For Your Eyes Only and Al Nofi's CIC are all trademarks of
Privacy Policy