Weapons: Too Hot To Handle

Archives

December 26, 2014:   The German army has a major problem with claims, many of them now documented, that its standard assault rifle, the G36, suffers accuracy and reliability problems when the barrel gets very hot. This tends to happen when the rifle fires a lot of rounds in a short period. Despite formal investigations and test results that back up the complaints of the troops the German the government has ordered yet another investigation and a temporary halt in purchases of G36s. The G36 is a 3.3 kg (7.3 pound), 999mm (39 inch) long (758mm with stock folded) 5.56mm assault rifle. Effective range is 800 meters and it can use a 30 or 100 round magazine and is an improvement on the M16 design from the 1960s. On paper the G36 was a success, in combat it was not.  

The reliability of the G36 in combat first became an issue when the G36 was used a lot in combat during hot weather in Afghanistan. There were incidents where hours of combat caused several very real problems. One of the more obvious problems was the polymer (plastic) parts of the rifle getting a bit soft when the metal parts got very hot due to heavy use in a short period of time. The barrel and receiver could move a tiny bit under those conditions and that threw off accuracy to a small degree that became especially noticeable only at longer (over 200 meters) ranges. No one has come up with a practical (workable and affordable) solution for that. At first the German government insisted the problem has to do with bad ammunition but the ammo manufacturers denied that and were able to make a convincing case. Then, in 2010 came multiple reports, confirmed by many witnesses and cell phone photos, of the heat related problems and total failure of the rifle in some cases. German politicians and procurement officials have been trying to make all this go away ever since. The government officials do not want to admit they made a major mistake in putting the G36 into service. They also don’t want the major expense of replacing the G36 with a better design.

The G36 has been the German infantry assault rifle since 1997. It was very popular initially, especially since it used a short-stroke piston system. The M16s uses gas-tube system, which results in carbon being blown back into the chamber. That leads to carbon build up, which results in jams (rounds getting stuck in the chamber, and the weapon unable to fire.). The short-stroke system also does not expose parts of the rifle to extremely hot gases (which wears out components more quickly). As a result, rifles using the short-stroke system, rather than the gas-tube, are more reliable, easier to maintain and last longer. That was the good news, the bad news stayed hidden for a decade.

Meanwhile heat has long been a problem for infantry weapons, especially those capable of automatic fire. The mass media is prone to misinterpreting these effects. For example the mass media is fond of talking about American assault rifles overheating and jamming. Some of the reports displayed a remarkable ignorance of how military rifles operate. A typical bit of misinformation reported rifle barrels white hot with heat. That's a physical impossibility, because of the metal used for these rifles. Long before the rifle barrels turned any color from heat, rounds would automatically fire ("cook off") from the heat, and the barrels would fail (split apart). The reporters also seemed unaware of how automatic weapons handle heat. Assault rifles are built to fire about once every four seconds for hours, without any heat problems. Machine-guns do have heat problems, and are designed with easily removable barrels, so you can switch in a fresh barrel. In short, any automatic weapon will overheat if you put too many rounds through it in too short a time. The G36 can fire over 12 rounds a second, interrupted only by the few seconds it takes to insert a new magazine. In heavy combat troops fire their weapons as fast as they can because it is a matter of life and death. But all that firing is not what the G36 was designed to handle.

German troops are taught all about this heat problem, and are reminded that they must either cope with it, or risk death. The G36 problem is what engineers consider “acceptable” given the design. It is always possible, especially in a desperate combat situation, to use weapons in ways they were not designed for.  Well trained troops are taught the consequences of certain extreme situations, so that at least they know what to expect.

In the U.S. military assault rifle problems tend to be about rifles jamming (and not because of heat problems). This goes back to the decades old argument about replacing the recoil system in American assault rifles. This came to a head (again) in 2007, when the army ran more tests on its M-4 rifle, involving dust and reliability. Four weapons were tested. The M4, the XM8, SCAR (Special Operations Forces Combat Assault Rifle) and the H&K 416 (an M4 with the more dust resistant components of the XM8 installed).

The testing consisted of exposing the weapons to 25 hours of heavy dust conditions over two months. During that testing period, 6,000 rounds were fired from each of ten weapons of each type. The weapons with the fewest failures (usually jams) were rated highest. Thus the XM8 finished first, SCAR second, 416 third and M4 last. In response, the army said it was satisfied with the M4s performance, but was considering equipping it with a heavier barrel (to lessen overheating) and more effective magazines (27 percent of the M4s 882 jams were magazine related.) The army noted that the M4 fired over 98 percent of its rounds without problems. The army had been forced by Congress to conduct the tests. Congress was responding to complaints by the troops.

In dusty places like Iraq and Afghanistan, you have to clean your M16 and M4 rifles constantly, otherwise the combination of carbon and dust in the chamber will cause jams. The army and marines both decided to stick with their current weapons, rather than adopt an easier to maintain weapon, like the XM8 or H&K 416, because of the billion or so dollars it would cost to switch rifles.

If the issue were put to a vote, the troops would vote for a rifle using a short-stroke system (like the XM8, SCAR, G36 or H&K 416). But the military is not a democracy, so the troops spend a lot of time cleaning their weapons, and hoping for the best. The debate involves two intertwined attitudes among senior army commanders. First, they don't want the hassle, and possible embarrassment, of switching to a new rifle. Second, they are anticipating a breakthrough in weapons technology that will make a possible a much improved infantry weapon. This is likely to happen later, rather than sooner, but the generals keep obsessing over it.

Earlier efforts to just get the troops a more reliable rifle have failed. Back in 2005, the U.S. Army's design for a new assault rifle, the XM8, was cancelled. The XM8 manufacturer then incorporated one of the key components of the XM8, into M4 rifles, and calls the hybrid the H&K 416. Heckler & Koch (H&K) based the XM8 design on an earlier H&K rifle, the G36. SOCOM is using the 416, but no one else is (except for a few police departments). SOCOM has not complained of heat problems with the 416, in large part because SOCOM troops are highly trained and experienced and know well the heat risks and how to cope. Some German troops can handle the heat problems like their SOCOM counterparts but many German troops cannot and you must either change the weapon or change the users.

 

 

 

 

X

ad

Help Keep Us From Drying Up

We need your help! Our subscription base has slowly been dwindling.

Each month we count on your contribute. You can support us in the following ways:

  1. Make sure you spread the word about us. Two ways to do that are to like us on Facebook and follow us on Twitter.
  2. Subscribe to our daily newsletter. We’ll send the news to your email box, and you don’t have to come to the site unless you want to read columns or see photos.
  3. You can contribute to the health of StrategyPage.
Subscribe   contribute   Close